Product ID:LPS CFC-FREE ELECTRO CONTACT CLEANER
MSDS Date:11/07/1996
FSC:6850
NIIN:01-412-0044
Status Code:A
MSDS Number: CJMHX

LPS LABORATORIES,INC.

4647 HUGH HOWELL ROAD
TUCKER, GA 30084-5096
US

Emergency Phone: 770-934-7800

Info Phone: 770-934-7800

Preparer: JOHN ROUDEBUSH

Cage: 66724

LPS LABORATORIES, INC.

TUCKER, GA 30085-5052 US

Telephone: 404-934-7800

Cage: 66724

ISOHEXANE

CAS: 107-83-5

RTECS: SA2985000

ISO-PROPANOL; ISOPROPYL ALCOHOL

CAS: 67-63-0

RTECS: NT8050000

OSHA PEL 980 MG/M3;400 PPM

ACGIH TLV: 983 MG/M3;400 PPM

N-HEXANE

CAS: 110-54-3

RTECS: MN9275000

OSHA PEL 1800 MG/M3;500 PPM

EPA Report Quantity: 1 LB

DOT Report Quantity: 1 LB

LD50 LC50 Mixture:LD50 (ORAL, RAT) IS UNKNOWN.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:TARGET ORGANS: EYE, SKIN, CENTRAL
NERVOUS SYSTEM, RESPIRATORY TRACT. ACUTE- VAPOR AND LIQUID MAY
CAUSE EYE IRRITATION. PROLONGED/REPEATED SKIN CONTACT MAY CAUSE
DRYNESS. CAN BE ABSORBED THROUGH SKIN. INHALATION MAY CAUSE
HEADACHE, LIGHT HEADEDNESS, CENTRAL NERVOUS SYSTEM DEPRESSION. MAY
IRRITATE MUCOSAL TISSUE AT HIGH CONCENTRATION. INGESTIOPN IS
UNLIKELY ROUTE OF EXPOSURE. HOWEVER, MINUTE AMOUNTS ASPIRATED INTO
LUNGS DURING INGESTION MAY CAUSE CHEMICAL PNEUMONIA. CHRONIC -
UNKNOWN.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION, HEADACHE, NAUSEA, VOMITING,
DIZZINESS, SKIN DEFATTING AND DRYNESS, BLURRED VISION, TEARING
Medical Cond Aggravated by Exposure:PERSONS WITH PRE-EXISTING
RESPIRATORY DISORDERS.

First Aid:GET MEDICAL HELP IF SYMPTOMS PERSIST. INHALED: REMOVE TO
FRESH AIR. PROVIDE OXYGEN IF NEEDED. EYES: FLUSH WITH WATER FOR 15
MINUTES, HOLDING EYELIDS OPEN. SKIN: WASH WITH SOAP & WATER. APPLY
MEDICATED CREAM. INGESTION: DO NOT INDUCE VOMITING. GET MEDICAL
ATTENTION IMMEDIATELY. NEVER GIVE ANYTHING BY MOUTH TO AN
UNCONSCIOUS PERSON.

Flash Point Method:TCC
Flash Point:<-17.8C, 0.F
Lower Limits:1.2
Upper Limits:7.7
Extinguishing Media:CARBON DIOXIDE, FOAM, DRY CHEMICAL.
Fire Fighting Procedures:WEAR NIOSH-APPROVED SELF-CONTAINED BREATHING
APPARATUS. COOL FIRE-EXPOSED CONTAINERS WITH WATER SPRAY.
Unusual Fire/Explosion Hazard:VAPOR IS HEAVIER THAN AIR AND CAN TRAVEL
CONSIDERABLE DISTANCE TO A SOURCE OF IGNITION AND FLASH BACK.
CONTAINERS MAY RUPTURE DUE TO VAPOR PRESSURE BUILDUP.

Spill Release Procedures:WEAR PROTECTIVE EQUIPMENT. ELIMINATE SOURCES
OF IGNITION. VENTILATE AREA. CONTAIN AND PICK UP SPILL WITH
NON-FLAMMABLE ABSORBENT SUCH AS SAND OR EXPLOSION-PROOF PUMP.
GROUND ALL HANDLING EQUIPMENTS. P REVENT LIQUID FROM ENTERING
SEWERS OR WATERWAYS. STORE IN CLOSED CONTAINERS. DO NOT FLUSH
PRODUCT TO SEWER. TRANSFER TO DRUMS USING NON-SPARKING TOOLS.
Neutralizing Agent:NOT RELEVANT

Handling and Storage Precautions:STORE IN COOL, VENTILATED AREA, AWAY
FROM FLAMES, SPARKS, HOT SURFACES & STRONG OXIDIZING AGENTS. KEEP
CONTAINER TIGHTLY CLOSED. STORE BELOW 100F.
Other Precautions:EXTREMELY FLAMMABLE. "EMPTY" CONTAINERS RETAIN
RESIDUE AND CAN BE DANGEROUS. FOLLOW ALL LABEL INSTRUCTIONS. AVOID
REPEATED/PROLONGED SKIN CONTACT. KEEP OUT OF REACH OF CHILDREN. DO
NOT BREATHE VAPORS.

Respiratory Protection:IF TLV IS EXCEEDED, WEAR NIOSH-APPROVED ORGANIC
VAPOR RESPIRATOR OR SELF-CONTAINED BREATHING APPARATUS. NONE
REQUIRED IF GOOD VENTILATION IS MAINTAINED.
Ventilation:MECHANICAL (GENERAL AND/OR LOCAL EXHAUST, EXPLOSION-PROOF)
VENTILATION TO MAINTAIN EXPOSURE BELOW TLV(S).
Protective Gloves:USE SOLVENT RESISTANT GLOVES (BUNA-N OR NEOPRENE).
Eye Protection:CHEMICAL SAFETY GOGGLES
Other Protective Equipment:EYE WASH STATION & SAFETY SHOWERS SHOULD BE
AVAILABLE IN THE IMMEDIATE VICINITY OF ANY POTENTIAL EXPOSURE.
Work Hygienic Practices:OBSERVE GOOD INDUSTRIAL HYGIENE PRACTICES AND
RECOMMENDED PROCEDURES. WASH AFTER HANDLING AND BEFORE EATING OR
DRINKING.
Supplemental Safety and Health

HCC:F2
NRC/State Lic Num:NOT RELEVANT
Boiling Pt:=60.6C, 141.F
Vapor Pres:352 @ 100F
Vapor Density:3.0
Spec Gravity:0.665
Evaporation Rate & Reference:<1 (ETHYL ETHER=1)
Solubility in Water:< 20%
Appearance and Odor:CLEAR, COLORLESS LIQUID - MILD ALCOHOL ODOR
Percent Volatiles by Volume:100

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS, OXYGEN
Stability Condition to Avoid:HIGH HEAT, OPEN FLAMES, SPARKS, HOT
SURFACES, ELECTRICAL ARCS, OTHER SOURCES OF IGNITION
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE

Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH FEDERAL, STATE AND
LOCAL REGULATIONS FOR FLAMMABLE HYDROCARBONS OR RECLAIM BY
DISTILLATION.

Transport Information:FLAMMABLE LIQUID (HEXANES, ISOPROPANOL), 3,
UN1993, PGII

SARA Title III Information:YES, CAS # 110-54-3

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.